Home Page American Government Reference Desk Shopping Special Collections About Us Contribute



Escort, Inc.






GM Icons
By accessing/using The Crittenden Automotive Library/CarsAndRacingStuff.com, you signify your agreement with the Terms of Use on our Legal Information page. Our Privacy Policy is also available there.

Denial of Motor Vehicle Defect Petition


American Government Topics:  Jeep Grand Cherokee

Denial of Motor Vehicle Defect Petition

Kenneth N. Weinstein
National Highway Traffic Safety Administration
February 24, 1998

[Federal Register: February 24, 1998 (Volume 63, Number 36)]
[Notices]               
[Page 9294-9295]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr24fe98-151]

-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

National Highway Traffic Safety Administration

 
Denial of Motor Vehicle Defect Petition

AGENCY: National Highway Traffic Safety Administration (NHTSA), 
Department of Transportation.

ACTION: Denial of petition for a defect investigation.

-----------------------------------------------------------------------

SUMMARY: This notice sets forth the reasons for the denial of a 
petition submitted to NHTSA under 49 U.S.C. 30162, requesting that the 
agency commence a proceeding to determine the existence of a defect 
related to motor vehicle safety.

FOR FURTHER INFORMATION CONTACT: Dr. George Chiang, Office of Defects 
Investigation, NHTSA, 400 Seventh Street, SW, Washington, DC 20590. 
Telephone: (202) 366-5206.

SUPPLEMENTARY INFORMATION: Mr. and Mrs. Scott Montreuil of Ramsey, 
Minnesota, submitted a petition dated October 1, 1997, requesting that 
an investigation be initiated to determine whether 1993 Chrysler Jeep 
Grand Cherokees contain a defect related to motor vehicle safety within 
the meaning of 49 U.S.C. Chapter 301. The petition alleges that 1993 
Chrysler Jeep Grand Cherokees have a defective viscous coupling that 
could cause the steering to bind and lock up, and possibly affect the 
vehicle's braking.
    Although not all Jeep Grand Cherokees utilize a viscous coupling, 
some 1993 through 1995 Jeep Grand Cherokees are equipped with a Quadra-
Trac transfer case. An integral part of the Quadra-Trac transfer case 
is its viscous coupling, a speed-sensitive device that controls torque 
output between the front and rear drive shafts.

[[Page 9295]]

The housing of the viscous coupling contains high viscosity silicone 
fluid and specially engineered metal plates splined alternately to an 
inner and outer drum. When there is a difference in front-to-rear axle 
speed, such as when the rear wheels slip, the resulting friction 
between the metal plates increases the temperature inside the unit. 
This causes the fluid to expand, building pressure that moves the 
plates together. This occurs almost instantaneously in two modes: the 
``shear'' mode, when momentary speed differences occur such as in 
cornering or tight turns, causing the plates to move near each other, 
or the ``hump'' mode, when high-speed differences occur for a longer 
period of time, such as in deep snow or on off-road trails, causing the 
plates to lock and the front and rear drive shafts to turn at the same 
speed for maximum traction. As traction is gained, the fluid cools, and 
the plates separate.
    When the viscous coupling fails, it may remain in one of the above 
two modes all the time, regardless of whether there is a difference 
between front-and-rear axle speed. If the coupling fails in the 
``hump'' mode on dry pavement, it may cause vehicle hopping/bucking 
during turns, resulting in rapid wear of tires.
    NHTSA drove a Jeep Grand Cherokee with a simulated failure of the 
viscous coupling in the ``hump'' mode on dry pavement at various 
speeds. Some hopping/bucking was experienced while the vehicle executed 
turns. However, no steering or braking problems were experienced at any 
time.
    A review of agency data files, including information reported to 
the Auto Safety Hotline by consumers, indicated that, aside from the 
petition, there were no other reports concerning failure or malfunction 
of the viscous coupling in 1993 Jeep Grand Cherokees. There was a 
report pertaining to transmission lockup when the engine was started, 
but this was not related to a failure of the viscous coupling.
    Chrysler Corporation has received 40 complaints concerning failure 
or malfunction of the viscous coupling in the transfer case of 1993 
Jeep Grand Cherokees. Five of these complaints report handling 
problems, such as vehicle hopping during turns. The remaining 35 
complaints are solely related to financial assistance issues. No 
crashes or injuries were reported.
    The agency has analyzed available information concerning the 
problem alleged in the petition. Based on its understanding of viscous 
couplings, NHTSA believes that the failure or malfunction of the 
viscous coupling in the subject vehicles cannot cause lockup of the 
steering or adversely affect the brake system.
    For the reasons presented above, it is unlikely that NHTSA would 
issue an order for the notification and remedy of a safety-related 
defect in the subject vehicles at the conclusion of the investigation 
requested in the petition. Therefore, in view of the need to allocate 
and prioritize NHTSA's limited resources to best accomplish the 
agency's safety mission, the petition is denied.

    Authority: 49 U.S.C. 30162(d); delegations of authority at CFR 
1.50 and 501.8.

    Issued on: January 29, 1998.
Kenneth N. Weinstein,
Associate Administrator for Safety Assurance.
[FR Doc. 98-4627 Filed 2-23-98; 8:45 am]
BILLING CODE 4910-59-M




The Crittenden Automotive Library